Green Synthesis, Characterization and Process Optimization of a Clerodendrum inerme-Mediated ZnO/g-C₃N₄ Heterojunction for Congo Red Photodegradation
J. Environ. Nanotechnol., Volume 15, No 3 (September 2026) pp. 564-577
Abstract
The aim of this study was to develop an environmentally sustainable ZnO/g-C₃N₄ heterojunction photocatalyst for visible-light degradation of Congo red using Clerodendrum inerme leaf extract as a green complexing and growth-controlling medium. To address the limitations associated with conventional chemical synthesis and rapid photogenerated charge-carrier recombination, ZnO was coupled with thermally prepared g-C₃N₄ through a plant-assisted route and characterized by XRD, FTIR, SEM–EDX, UV–Vis DRS, and BET analyses. XRD confirmed the coexistence of hexagonal wurtzite ZnO and layered g-C₃N₄ without detectable crystalline impurities, while the ZnO crystallite size decreased from approximately 24.8 nm to 17.6 nm following composite formation. The apparent optical bandgap values were approximately 3.20, 2.68, and 3.13 eV for ZnO, g-C₃N₄, and ZnO/g-C₃N₄, respectively, while the BET surface area increased from 90.0 to 107.0 m² g⁻¹. Under visible-light LED irradiation, ZnO/g-C₃N₄ achieved approximately 87% Congo red degradation within 120 min compared with 65% for g-C₃N₄. The degradation followed pseudo-first-order kinetics, and scavenger experiments identified superoxide radicals as the dominant reactive species, with photogenerated holes and hydroxyl radicals also contributing. These findings demonstrate the potential of Clerodendrum inerme-mediated ZnO/g-C₃N₄ for photocatalytic treatment of dye-contaminated wastewater. Future investigations should evaluate mineralization efficiency, repeated-use stability, catalyst leaching, toxicity, and performance in real industrial wastewater containing mixed contaminants.
Full Text
Reference
Alasmari, S. M., Albogami, B. Z. and Nenaah, G. E., Potential of using Clerodendrum inerme extracts, essential oil, and biosynthesized silver nanoparticles as ecofriendly natural pesticides for controlling the rust floor beetle, Tribolium castaneum infesting grain products in stores, J. Stored Prod. Res., 114, 102715 (2025a).
https://doi.org/10.1016/j.jspr.2025.102715
Alasmari, S. M., Albogami, B. Z., Nenaah, G. E. and Nenaah, S. G., Bio-activities of Clerodendrum inerme extracts, essential oil, main terpenes and Ag nanoparticles against the stable fly, Stomoxys calcitrans (Diptera: Muscidae) and their non-target effects against its parasitoid, Spalangia cameroni (Hymenoptera: Pteromalidae) and earthworms, Veteri. Parasitol., 337, 110497 (2025b).
https://doi.org/10.1016/j.vetpar.2025.110497
Al-Enazi, N. M., Optimized synthesis of mono and bimetallic nanoparticles mediated by unicellular algal (diatom) and its efficiency to degrade azo dyes for wastewater treatment, Chemosphere, 303, 135068 (2022).
https://doi.org/10.1016/j.chemosphere.2022.135068
Amale, A. B., Satishkumar, P., Bhagat, P. R., Motghare, M. S. and Krishnaraj, C., Green Synthesis of ZnO Nanoparticles Using Azadirachta indica Leaf Extract for Rapid Catalytic Degradation of Organic Pollutants, J. Environ. Nanotechnol., 15(2), 151–161 (2026).
https://doi.org/10.13074/jent.2026.06.2612082
Anuradha, G., Snega, S., Dinesh, R. and Manimekalai, R., Dendrophthoe falcata extract mediated Fe3O4 nanoparticles: A functional agent for dye degradation and inflammation mitigation, J. Mol. Struct., 1319, 139433 (2025).
https://doi.org/10.1016/j.molstruc.2024.139433
Chauhan, A., Verma, R., Dhatwalia, J., Kumari, A., Dutta, V., Chandrasekaran, G., Ghotekar, S., Kaur, M., Vignesh, J. and Thakur, S., Phyto-mediated synthesis of pure phase α-Bi2O3 nanostructures using Rubus ellipticus plant extract: photocatalytic activity and antimicrobial efficacy, Biomass Convers. Biorefin., 14(20), 25103–25122 (2024).
https://doi.org/10.1007/s13399-023-04679-8
Dahiya, S., Sharma, R., Gautam, P., Panchal, P., Chaudhary, S., Sharma, A., Almáši, M. and Nehra, S. P., Eco-friendly phytofabrication of Ficus Benjamina L. based ZnO-doped g-C3N4 nanocomposites for remarkable photocatalysis and antibacterial applications, Chemosphere, 339, 139707 (2023).
https://doi.org/10.1016/j.chemosphere.2023.139707
Ekennia, A., Uduagwu, D., Olowu, O., Nwanji, O., Oje, O., Daniel, B., Mgbii, S. and Emma-Uba, C., Biosynthesis of zinc oxide nanoparticles using leaf extracts of Alchornea laxiflora and its tyrosinase inhibition and catalytic studies, Micron, 141, 102964 (2021).
https://doi.org/10.1016/j.micron.2020.102964
Ganvir, H. V., Musrif, P. G., Satishkumar, P., Kadam, A. D., Saminathan, R. and Krishnaraj, C., Sustainable Synthesis of MgO Nanoparticles from Clerodendrum inerme Bast Fiber Extract: Physicochemical Characterization and Antibacterial Performance, J. Environ. Nanotechnol., 15(2), 380–388 (2026).
https://doi.org/10.13074/jent.2026.06.2622227
Hao, J., Wen, Y., Jiao, Y., Zhao, Z., E, H., Wang, J., Wang, S., Zuo, M., Liu, J., Cui, S. and Yang, X., Enhanced photocatalytic deoxynivalenol degradation using ZnO/g-C3N4 S-scheme heterojunction, Chem. Phys. Lett., 882, 142459 (2026).
https://doi.org/10.1016/j.cplett.2025.142459
Hassan, F., Backer, S. N., Almanassra, I. W., Ali Atieh, M., Elbahri, M. and Shanableh, A., Solar-matched S-scheme ZnO/g-C3N4 for visible light-driven paracetamol degradation, Sci. Rep., 14(1), 12220 (2024).
https://doi.org/10.1038/s41598-024-60306-0
Indira, K., Shanmugam, S., Hari, A., Vasantharaj, S., Sathiyavimal, S., Brindhadevi, K., El Askary, A., Elfasakhany, A. and Pugazhendhi, A. Photocatalytic degradation of congo red dye using nickel–titanium dioxide nanoflakes synthesized by Mukia madrasapatna leaf extract, Environ. Res., 202, 111647 (2021).
https://doi.org/10.1016/j.envres.2021.111647
Kashyap, D. N., Shalom, N., Mayakannan, S., Muthuraj, M., Thanikasalam, A. and Ahmed, A. A., Comparative Green and Wet-chemical Synthesis of ZnO Nanoparticles: Enhanced Photocatalytic and SERS Performance of Defect-rich Nanostructures, J. Environ. Nanotechnol., 15(2), 162–175 (2026).
https://doi.org/10.13074/jent.2026.06.2612090
Khan, Z. U. H., Khan, A., Shah, N. S., Din, I. U., Salam, M. A., Iqbal, J., Muhammad, N., Imran, M., Ali, M., Sayed, M. and Gohar, M. A., Photocatalytic and biomedical investigation of green synthesized NiONPs: Toxicities and degradation pathways of Congo red dye, Surf. Interf., 23, 100944 (2021).
https://doi.org/10.1016/j.surfin.2021.100944
Khawale, V. R., Kumar, R., Satishkumar, P., Haldar, B., Deepa, B., Saminathan, R., Veeramanikandan, P., Packirisamy, A. S. B. and Selvaraju, M., Study on Electrochemical Stability and Charge Transfer Efficiency for the Development of High-Performance Supercapacitors Using Iron Oxide (Fe2O3) Nanorods, J. New Mater. Electrochem. Syst., 27(3), 163–171 (2024).
https://doi.org/10.14447/jnmes.v27i3.a01
Langa, C., Mabuba, N., Mahlaule-Glory, L. M., Motaung, D. E., Tetana, Z. and Hintsho-Mbita, N. C., Enhanced photocatalytic degradation of dyes and pharmaceutical pollutants using Fe/TiO2-carbon nanospheres from Sutherlandia Frutescence, Int. J. Environ. Anal. Chem., 106(4), 790–820 (2026).
https://doi.org/10.1080/03067319.2025.2524833
Langa, C., Mathipa, M., Mabuba, N. and Hintsho-Mbita, N. C., Effect of calcination temperature on the structural and photocatalytic properties of nickel sulfide nanoparticles for dye degradation and antibacterial applications, Chem. Phy. Impact, 11, 100913 (2025).
https://doi.org/10.1016/j.chphi.2025.100913
Lekshmi, G. S., Ramasamy, T., Bazaka, O., Levchenko, I., Bazaka, K., Govindan, R. and Mandhakini, M., Antioxidant, Anti-Bacterial, and Congo Red Dye Degradation Activity of AgxO-Decorated Mustard Oil-Derived rGO Nanocomposites, Mol., 27(18), 5950 (2022).
https://doi.org/10.3390/molecules27185950
Mathialagan, A., Manavalan, M., Venkatachalam, K., Mohammad, F., Oh, W. C. and Sagadevan, S., Fabrication and physicochemical characterization of g-C3N4/ZnO composite with enhanced photocatalytic activity under visible light, Opt. Mater., 100, 109643 (2020).
https://doi.org/10.1016/j.optmat.2019.109643
Mayakannan, S., Rathinam, R., Saminathan, R., Deepalakshmi, R., Gopal, M., Hillary, J. J. M., Nanthakumar, S., Ganvir, V. Y. and Singh, P., Analysis of Spectroscopic, Morphological Characterization and Interaction of Dye Molecules for the Surface Modification of TiB2 Nanoparticles, J. Nanomater., 2022(1), 1033216 (2022).
https://doi.org/10.1155/2022/1033216
Mohanta, Y. K., Mishra, A. K., Panda, J., Chakrabartty, I., Sarma, B., Panda, S. K., Chopra, H., Zengin, G., Moloney, M. G. and Sharifi-Rad, M., Promising applications of phyto-fabricated silver nanoparticles: Recent trends in biomedicine, Biochem. Biophy. Res. Commun., 688, 149126 (2023).
https://doi.org/10.1016/j.bbrc.2023.149126
Prajapati, A. K. and Mondal, M. K., Novel green strategy for CuO–ZnO–C nanocomposites fabrication using marigold (Tagetes spp.) flower petals extract with and without CTAB treatment for adsorption of Cr(VI) and Congo red dye, J. Environ. Manage., 290, 112615 (2021).
https://doi.org/10.1016/j.jenvman.2021.112615
Prisrin, S. A., Priyanga, M., Ponvel, K. M., Kaviarasan, K. and Kalidass, S., Plant Mediated Approach for the Fabrication of Nano CuO–NiO Mixed Oxides Using Aqueous Extract of Mimusops Elengi Leaf: Green Synthesis, Characterization and Antibacterial Activity Studies, J. Clust. Sci., 33(2), 765–772 (2022).
https://doi.org/10.1007/s10876-021-02016-5
Senthilkumar, S. and Govindasamy, K., Green Synthesis of Mn-Doped ZnO Nanoparticles Using Ipomoea Staphylina Leaf Extract: Characterization and Application of Photocatalytic Dye Degradation, Antibacterial and Antioxidant Activity, Chem. Select, 9(35), e202402347 (2024).
https://doi.org/10.1002/slct.202402347
Ullah, M. A., Robel, F. N., Bahadur, N. M., Bashar, M. S., Khan, S., Ahmed, M. F., Ahmed, S. and Sahadat Hossain, M., Plant Extract-Mediated Synthesis of Nano-Crystallite TiO2 for the Efficient Photocatalytic Degradation of Textile Effluent and Antibiotics, Chem. Asian J., 20(23), e00352 (2025).
https://doi.org/10.1002/asia.202500352
Utomo, W. P., Afifah, P. A. I., Rozafia, A. I., Mahardika, A. A., Santoso, E., Liu, R. and Hartanto, D., Modulation of particle size and morphology of zinc oxide in graphitic carbon nitride/zinc oxide composites for enhanced photocatalytic degradation of methylene blue, Surf. Interf., 46, 104017 (2024).
https://doi.org/10.1016/j.surfin.2024.104017
Van Thuan, D., Nguyen, T. B. H., Pham, T. H., Kim, J., Hien Chu, T. T., Nguyen, M. V., Nguyen, K. D., Al-onazi, W. A. and Elshikh, M. S., Photodegradation of ciprofloxacin antibiotic in water by using ZnO-doped g-C3N4 photocatalyst, Chemosphere, 308, 136408 (2022).
https://doi.org/10.1016/j.chemosphere.2022.136408
Velmani, V., Balaji, M., Rajesh, P., Parethe, G. T. and Kavica, S., Biosynthesis of Zinc Oxide Nanoparticles using Cleome gynandra Extract and Evaluation of its Cytotoxic Activities on A549 Cell Line, J. Environ. Nanotechnol., 13(1), 162-171 (2024).
https://doi.org/10.13074/jent.2024.03.241523
Younas, M. U., Usman, A., Kashif, A. R., Zahoor, A. and Haider, F., Green Synthesis of TiO2 NPs Using Agave americana Leaves: Antioxidant, Cytotoxicity, and Photocatalytic Activity, Chem. Select, 9(44), e202404050 (2024).
